The most recently reported issues are listed below. They indicated that the gear box rebuilders only replaced the bearings, not the worn-out gears within the box. The contact owns a 2008 Ford F-250. all problems of the 2005 Ford F-250 . Rebuilder purchased motocraft rebuilt steering boxes from Ford. Steering Ford 2016 . Read details... Power steering bracket broke. I have started experiencing a vibration in the front end of my truck. Owner has taken truck to dealership several times for replacement of steering box, which was replaced 3 times. Ford. I replaced the steering link and adjusted the steering gear box. The number one most common problem is related to the vehicle's steering This article applies to the Ford F-150 (2004-2014) and the Ford F-250, F-350 Super Duty (2005-2014). Ford F-250 owners have reported 2,288 steering related problems since 1996. Upon inspection, the mechanics urged us to contact Ford due to this being a manufacturer's defect. On my 2005 Ford diesel F250, after 126000 miles, steering became very loose. Compare With Other Models Consequence. The number one most common problem is related to the hydraulic power assist steering system (31 problems). Sixty days later the steering gear box bound up and would not allow the wheels to be turned. Get a free detailed estimate for a repair in your area. I have been waiting on a steering box for 11 months for an 08 f250. Ford added a steering damper and i had to purchase tires to supposedly correct this problem. 2000 Ford F-250 steering problems with 64 complaints from F-250 owners. The trucks involved are equipped with a 6.4-liter engine. Steering gear box bolt failure, when bolts snapped off frame, leaving gear box dangling, dlr replaced steering gear box and bolts, months prior exp erratic shattering and steering control when braking. (Page 1 of 3) (Page 1 of 3) CarComplaints.com : Car complaints, car problems and defect information Turning the steering would not turn the wheels. The worst complaints are power steering not working properly, steering play. A little better. The kits were sold as an accessory for certain 2005-2021 Ford F-250 4X4 and F-350 4X4 pickup trucks. this has happened probably 20 times or so. A Ford F 250 Super Duty Steering Gearbox Replacement costs between $903 and $963 on average. NHTSA has opened an investigation into an estimated 340,000 2008 Ford F-250 and F-350 Super Duty trucks after complaints of loss of steering capability. Refused to replace any parts. See This information may be … Since I have a Rancho steering stabilizer I'm going to try and exchange under warranty just to eleminate. all problems of the 1999 Ford F-250 . Problem Is Getting Worse Causing Unsafe Driving In Intersections, Etc. Location: Destrehan, LA. The steering gear box was replaced. Cardone - Power Steering Gear (Part No. Inc which determined the defect. The second most common problem is related to the vehicle's steering wheel vibrate (177 problems). Has been getting worse and was pretty scarry today. This database includes information received by NHTSA from consumers either directly or as recorded by the Vehicle Safety Hotline. Be sure to maintain your truck's dependability with a new power steering gearbox for Ford F-250 from AutoZone. My truck was involved in a accident. The manufacturer was not notified of the failure. all problems of the 2006 Ford F-250 . The vehicle was repaired. 67 Power Steering Fluid Continuously Contaminates Even After Repeated Changes. Hydraulic Power Assist Steering System problems, Power Steering Hose, Piping, And Connections problems. It goes without saying that the steering in the vehicle you drive, in your case the Ford F-250, has to be in perfect condition. The contact inspected the vehicle and thought that the failure invovled the steering box and shaft. Traveling On Bumpy Roads At 55 To 60 Mph The Front End Will Start To Shake So Violently That In Order To Maintain Control I Had To Brake And Pull To The Side Of The Road. He said this is part of the death wobble problem in the f250. I. My wife driving vehicle at approx. My unit is all stock except for the super chip programmer I use … Four of these rebuilt boxes were tried on the truck. 05 ford f250 lariat 4x4. Ford F-250 RWD 4.9L Power Steering 1978, Remanufactured Power Steering Gear Box by Cardone Reman®. 1 per Pack. See ... 1977 Ford … Still when brakes are applied they travel almost to floor and feel like abs is a … read more The contact owns a 2008 Ford F-250 suprerduty diesel. Find helpful customer reviews and review ratings for Detroit Axle - Complete Power Steering Gear Box Assembly - for Ford Expedition, F-150 & F-250 at Amazon.com. Hazing is when the teeth of the belt become shiny. Open the hood and look at the belt wrapped around the power steering pump pulley on the driver's side of the engine bay. NHTSA — Steering: Gear Box (Other Than Rack And Pinion) Problems . While driving my 2019 Ford f250 on the highway at around 55 mph ,hit a small rough patch on road and the steering wheel started shaking violently, almost lost control . The worst complaints are steering. Table 1 shows the 25 most common steering problems. Took it, worked better, but problem not fixed. There was so much slop in the steering wheel and the wander was terrible. If you notice these or any other symptoms, it's time to replace your power steering gearbox for Ford F350. Ford, the complaint alleges, actively concealed that certain components within 2005-2019 F-250 and F-350 suspension systems are prone to failure, and has “routinely refused” to address the problem in proposed class members’ vehicles when it manifests. Table 1 shows 13 common steering related problems of the 2000 Ford F-250. Was able to lower speed and pulled over luckily me and my family did not crash. Steering looseness usually occurs in F-150s and F-250s due to some mechanical wear in the steering linkage. The contact owns a 2002 Ford F250. Lost all brakes and power steering. . Henry mills, mills automotive, marshall, missouri, inspected the vechicle, called me back almost immediately informing that this sector had broke on my truck. Please keep me informed of your findings. Head down to AutoZone, where our friendly staff is there to help you find the right product at the right price. Steering Gear Box problem of the 1997 Ford F-250 17 The vehicle has no adequate hydraulic filter on the release valve within the steering gear box to prevent valve comtamination and failure, causing the steering gear box to explode and total loss of power steering which resulted in an accident. The 2011 Ford F-250 has 75 NHTSA complaints for the steering at 63,121 miles average. The vehicle will be towed back the 60 miles today and we will not accept this vehicle. Builder said that this was a common problem with Ford gear boxes. When vehicle was directed to the right, consumer was unable to redirect vehicle to the left. Mention was made by the driver that the steering column seemed to go out. Updated 6/4/12. On my 2005 Ford diesel F250, after 126000 miles, steering became very loose. Rebuilder purchased motocraft rebuilt steering boxes from Ford. Motorcraft steering gear are designed for maximum performance and durability. See Table 1 … I suffered closed head trauma with amnesia in the accident. You may file your own complaint by calling the NHTSA Monday-Friday 8am to 8pm at (888) 327-4236, TTY: (800) … . Due to no control, I also side-swiped 2 parked cars. The technician diagnosed that the steering gear box needed to be replaced. 999 Posts . While driving though parking lot, experienced. 12 years of experience. Read honest and unbiased product reviews from our users. Vehicle is currently at lucas Chevrolet, mt. A popping noise or grinding noise heard while turning the steering wheel can come from a bad steering gear. See The whole truck was shaking. Had entire front end replaced including gear box. Vehicle was not using ANTI-LOCK BRAKES. ford f250 truck - front end suspension and 4 wheel drive problems. Our Ford f250 4x4 diesel truck has a steering problem. This is commonly known as the "death wobble". The vehicle was not repaired. When hitting a bump, etc in the road, the truck violently vibrates. (Page 1 of 4) (Page 1 of 4) CarComplaints.com : Car complaints, car problems and defect information I drive a Ford F-250 crew cab super duty. A new class action lawsuit alleges that Ford Super Duty pickup trucks are equipped with defective suspension components and steering linkage systems, causing them to vibrate and shake in what the lawsuit has dubbed a “death wobble.”. This information may be used by NHTSA during the investigation process. Manual Steering Gear Box Gearbox For Ford F100 F150 F250 F350 F-100 F-150 F-250 F-350 2WD 1965-1979 - BuyAutoParts 82-70071AN New 5.0 out of 5 stars 3 $364.67 $ 364 . At first the steering became hard, it felt like I didn't have power steering at all. Took vehicle to dealer, parts were not available. Took it to another Ford dealer, replaced the steering box, problem … 2002 F250 steering wandering I have had steering wandering issues and my 2002 F250 4x4 crew cab since I bought it a year ago as you have to constantly correct the steering. Ford F-250 owners have reported 2,355 steering related problems since 1996. Request Carlos. The manufacturer was notified. Ford F-250 Super Duty Power Steering Pressure Hose Replacement ... pressure hose transfers the high-pressure hydraulic output of the power steering pump to either a steering gear box or steering rack and pinion unit to create the power assist ... Andrew was able to fix it no with problems. Recall # 98v116000 Ford/lower control arm. The Contact Stated The Steering Wheel Pulled To The Left And To The Right When The Contact Made A Left Turn And The Contact Was Forced To Pull The Vehicle Onto The Side Of The Road. Model: F-250: System: Steering: Speed: 70: When Driving On Road/interstate Over 60 Mph And Hit A Rough Spot In The Road The Front End Shakes Violently. Steering Problem on the 2012 FORD F-250. While driving steering box totally failed, could not steer vehicle, steering box replaced by dealership, problem has not reoccurred, speed 25 mph. This indicates that the belt teeth are nearing failure or are excessively worn. Had entire front end replaced including gear box. Consumer had it analyzed by douglas b. See No better. Steering Problem on the 2013 FORD F-250. On may 11, 2001 I read an article in the kansas city star that indicated your agency was opening an investigation into "fractures in the steering gear shaft of Ford f-series super duty trucks. Truck is total. I was traveling @ 63 mph and was making a slight left bend . ©2020, CarProblemZoo.com All rights reserved. Carlos. If you are driving a 2012 Ford F-250, or if you are planning to purchase one, then it is important that you review reported Steering problems and defects.Total reports: 8. The front body clip was destroyed as well as the side doors and bed. This database includes information received by NHTSA from consumers either directly or as recorded by the Vehicle Safety Hotline. ... could this problem with the power steering box also cause a severe shimmy? The lawsuit includes current and former owners, as well as lessees of 2005 to 2019 Ford Super Duty F-250 and F-350 pickups. See Nhtsa recall # 98v11600 mfr # 98s17, consumer contacted the dealer to have recall corrected, dealer unaware of recall. Explanation of improvements made to CARDONE New steering gearboxes for 2005 -2010 Ford F250 and F350 Super Duty trucks.Was this video helpful? I decided I should bring this to your attention. FORD F-250 SD 2004 problem was reported in NEW BERLIN, WI. 2011 Ford F-250 Super Duty Lariat 3.31 ELOD 4X4 6.7 Power stroke 01/24/2017 110,000 MI S&B CAI SCT X4 Tuner Running a tow tune by AMDP https://amdieselperformance.ca/ ( on-demand exhaust brake from the AMDP tune).LED interior,LED AUX back-up,Westin HDX grill guard,High-idle,Aux 55 Gal Transfer tank,Draw-Tite Hide-A-Hitch gooseneck,LED puddle … NHTSA has opened an investigation into an estimated 340,000 2008 Ford F-250 and F-350 Super Duty trucks after complaints of loss of steering capability. If you are driving a 2012 Ford F-250, or if you are planning to purchase one, then it is important that you review reported Steering problems and defects.Total reports: 8. Ford F-250 TSBs. Wheel will not return to center without force and continued pressure. From my research I'm finding it's most likely the steering gear box! Put a ford one on. Ford F-250 Steering problems. The contact took the vehicle to the dealer the first time the failure occurred and the steering gear box was replaced, but the failure recurred after one week. ©2020, CarProblemZoo.com All rights reserved. Looking online seems this is an on-going problem for Ford. all problems of the 1997 Ford F-250 . Builder said that this was a common problem with Ford gear boxes. Vehicle was not using Cruise Control. Failure Date: 12/20/2013 I was safely operating my Ford f 250 on a concrete bridge in pine island florida . 2004 ford F250. Therefore, it is now on back order until June. The vehicle has no adequate hydraulic filter on the release valve within the steering gear box to prevent valve comtamination and failure, causing the steering gear box to explode and total loss of power steering which resulted in an accident. I only drive in the city or the highway and do not drive it off road. Noise When Turning. 6 alignments in 24,000 miles, a broken 14mm suspension bolt, a steering gearbox failure, 3 sets of brakes & rotor/caliper replacement indicates major design/material & quality problems. The wheel needs to be turned back left to unlock and this is not always possible. all problems of the 1996 Ford F-250 . This is a serious safety issue that Ford needs to correct immediately. What is the fix? Read details... My kids and I were driving on I-70 west coming from cambridge ohio to columbus. Please describe details. Updated 12/11/12 updated 12/12/12. I have a 2001 f250, 2015 f250 and a 2019 f250 and I have never had an issue with the steering. Your full-size Ford F-250 truck is a powerful workhorse that you can depend on to get the job done right. With age, power steering pumps, steering boxes, arms and most other components of the system wear out. Bolts on the power steering box broke in half causing loss of steering control. (1,760 problems). The contact took the vehicle to the dealer the first time the failure occurred and the steering gear box was replaced, but the failure recurred after one week. I too have the same problem 2000 F250 4x4 Super Duty Diesel 7.3 just started at 210,000 miles. Please also check out the statistics and reliability analysis of the 2006 Ford F-250 based on all problems reported for the 2006 F-250. With the help of a couple PSN members that convinced me to go to ford and buy one of their p/s pumps I did. Check the belt for cracks, chipping, peeling, or hazing. The vehicle would not stay in a straight path and it would swerve all over the lane. all problems of the 2001 Ford F-250 . 2013 Ford F-250 steering problems with 10 complaints from F-250 owners. steering problem - posted in 73-79 Ford Truck: i let my truck sit for about 6 months and finally i got the money to do some work and get her running and once i got her running the steering is messed up. 10.0. really awful Crashes / Fires: 2 / 0 Injuries / Deaths: 1 / 0 Average Mileage: 0 miles. Well after spending alot of time and money I finaly fixed my hard steering problem! Find out how to get the the slop out of the steering on your Ford Super Duty. Traveling On Bumpy Roads At 55 To 60 Mph The Front End Will Start To Shake So Violently That In Order To Maintain Control I Had To Brake And Pull To The Side Of The Road. We hit a rough spot in the road and the front end started shaking violently from side to side. Ford F-250 Super Duty 2005, Steering Gear Box by Motorcraft®. Scheduled an appointment. Ford customer relations is useless, could care less & is non-supportive. Updated November 2019.: 5. The contact stated the steering wheel pulled to the left and to the right when the contact made a left turn and the contact was forced to pull the vehicle onto the side of the road. The only issue I’ve had with any of these trucks was the DPF system suffocating the engine with gasses that should not be put back into the truck, but that’s not Fords fault, it’s the government’s fault. Car problem(s) with the 2013 FORD F-250. It doesn't matter how powerful your truck is if you can't control the steering due to a worn-out Ford F250 steering gear. Ford Motor Co. is recalling 538 service replacement steering gears that may have been installed on 2008-2010 model-year Ford F-250 and F-350 Super Duty diesel trucks in North America. The second most common problem is related to the steering (19 problems). Find help with Ford F-250 2016. when i turn the wheel there is power steering but it will bind up and then it will free up and then it will bind up whether im sitting still or moving. He contacted the local Ford dealer, who I understand went and looked at the vechile and informed mr. Mills that Ford had not issued any bulletins on the problem and could do nothing about it at this time. Vehicle went into a ditch as a result of consumer not being able to steer vehicle to the left. all problems of the 2009 Ford F-250 . Ford is recalling 538 replacement steering gears that may have been installed on 2008-'10 Ford F-250 and F-350 Super Duty diesel trucks in North America, the automaker said on Tuesday. Discussion Starter • #1 • May 7, 2012 (Edited) I have a 2003 F250 4X4. While driving, bolts that holds steering box to frame sheared off, one left hanging, caused loss of steering control. Power Steering Pump problem of the 2012 Ford F-250 10. Vehicle had 8 CYLINDERS. The contact stated that the vehicle became very difficult to steer while driving 30 mph. Death wobble is usually found in older trucks, and even my 01 drives fine. Ford still has us on a waiting list to get one. If you are driving a 2002 Ford F-250, or if you are planning to purchase one, then it is important that you review reported Steering problems and defects.Total reports: 3. I noticed right away that the steering seemed kind of "loose". Truck tends to wander across the road when it hits a seam in the road. Consumer had it analyzed by douglas b. Chisholm assc. . I let my foot off the accelerator and changed lanes. The contact owns a 2002 Ford f250. Hydraulic Power Assist Steering System problems. About These NHTSA Complaints: The NHTSA is the US gov't agency tasked with vehicle safety. Replaced powersteering pump, hydroboost, and steering box. The left wheel steering linkage was sheared off. Holly NJ. We had 2 occasions where we just missed being in an accident. Ford dealer also stated i needed an additional alignment to further correct. ... possibly causing the steering to lock up. I faxed the article to the shop repairing my truck. *tr . We live on a curve road and it's very dangerous. Power Steering Problems - posted in 73-79 Ford Truck: I have a 79 ford f150 4X4. *tr . While traveling at approximately 25 to 30 mph steering gear box failed. The steering gear box is the heart of the vehicle's steering … - I have a '05 F350 SD, SB, diesel, dually with 33K highway miles on the clock. This did not stop the shaking. None were any good. It's locking up when turning left to right. Gradually Over A One Year Period, Then Intermittent, Power Steering Gear Box Shaft Locks Up At Slow Speed Turns. Truck has never plowed snow nor went crashing through back woods rivers and streams. The contact stated the steering wheel pulled to the left and to the right when the contact made a left turn and the contact was forced to pull the vehicle onto the side of the road. The vehicle continues in the direction just prior to the lock. the wobble was so serious and scary. 35 mph, after coming out of a slight curve in road and slowing for a stop sign, she lost all steering control of vehicle hitting a guardrail and going into a ditch. 77 reviews. Ford F-250 owners have reported 20 Otherwise, neither you nor the passengers surrounding you are safe. See Vehicle Not Drivable At This Point. The dealer was notified who stated there was no recall and the parts were on national back order. The 1997 model year has been involved in the most campaigns with 314 bulletins. While driving approximately 62 mph, the steering wheel and both front tires began shaking without warning. The failure mileage was 36,000. I ignored his comments and simply assumed that he was driving too fast and lost control. all problems of the 2000 Ford F-250 . Here is the quick version. Car problem(s) with the 2012 FORD F-250. The steering gear, shock, inner tie rod end, pitman arm, drag link, sway bar bracket, and link kit were replaced. Consumer contacted the dealer in reference to recall number 98v116000, manufacturer's number 98s17. problems related to steering gear box (under the steering category). Vehicle was damaged. Ford will replace them under warranty because they state that the cracked bushing can affect steering, handling and braking.. if the bushings fall apart suddenly the driver of the vehicle can lose control and crash and kill someone.. my service advisor said he has mever seen the problem before.. being curious I looked at other vehicles on the lot.. every single F250 and F350 vehicle I … See Unable to get part through any dealership or junk yard in the united states. The contact owns a 2009 Ford f250. Vehicle Identification Number (VIN):1FTNX21P24E. The vehicle has also left me stranded 5 times for other not listed engine related failures. So at 32K I took it in, Ford said it needed new ball joints and the steering box needed adjusted. all problems of the 2008 Ford F-250 . We took it to the dealer in folsom CA, they replaced the steering stabilizer, which did not solve the problem. The most recently reported issues are listed below. Mileage was 45000 miles. The truck had no grass or dirt on the front undercarriage. Neither worked. View what other owners report, post your questions, and consult with on-line Ford experts. I was driving down a main city street at 30 mph when the steering gear sheared off, causing no steering control of the vehicle. The Contact Owns A 2002 ford F250. Owner is still experiencing a prolbem with truck after having recall work performed. Obviously, the easiest course of action would be to simply find a donor truck of approximately the same year as your own and swap the steering column and box from it. If you have to turn the steering wheel more than 1 inch in one direction before the tires turn, there is a problem with the steering gear. Put a parts store pump on. These include the steering shaft, the steering box, and the steering linkages consisting of the tie rods, ends, and damper. Through numerous attempts to get this part I have found that so many have been sold recently that the supply has been exhausted. 27-7569) Description. For details of each of the problem category, use the links in the table. The F-250 has been assigned 1,041 TSBs. Cause of failure is still unknown. We have tried aftermarket boxes but there not that great either. Vehicle Identification Number (VIN):1FTNX21P74E. Inspection by an ase certified mechanic revealed that the output from the steering box broke between gear box and pitman arm causing a total loss of steering control. Then might catch and turn quickly in the opposite direction. Broken steering box on a 2005 Ford F-250 has 28,500 miles, denied warranty. Complaints can be spread across multiple & redundant categories, & are not organized by problem. I recently purchased a used 2019 Ford F250 Super Duty XLT 4WD Long Bed 6.7 Powerstroke with 23000 miles on it. Steering Gear Box Sector Shaft problem of the 1999 Ford F-250 9 Failure Date: 09/25/2000 While driving there was no steering, the vehicle crossed an inbound lane and went into a ditch, tire was blown and tie rod had broken. After 8 years I got hard steering when not moving. Please attach the additional information. FORD F-250 SD 2004 drive type:4WD. Problem with your Ford F-250 Super Duty? So my first move was to replace the power steering pump. Steering column: If you decide to 'upgrade' to the Saginaw box, then this info pertains you to.Since the Saginaw box is about two inches longer than a manual-steering (or Bendix) box, your existing column will not work as is. The contact stated that while driving at 35 mph the steering gear box failed. since march of this year 2016, @ 90k miles, while driving down the road, traveling around 50 mph, the front suspension on my ford f250 started shaking and wobble uncontrollable. After research and speaking with my local alignment center he informed me that this is common on the 2019 f250. The 2015 Ford F-250 has 48 NHTSA complaints for the steering at 67,008 miles average. At any speed over 50 mph the truck starts shaking violently when driven over any small bump or seam in the road. See 1 per Pack. I have a 2006 F350 Diesel and have started having steering problems. Hitting a few bumps, the truck could end up across the white lines if you weren't paying attention. The vehicle had not been taken to the to the dealer, but the manufacturer had been notified. Although the early Ford steering box, most notably the ones used in all 1965-1970 Mustangs, has a bad reputation for being loose and allowing the car to wander about the road, the box is actually a very good and sound design. When the steering locks you can not do anything. In some cases, jerking steering wheel from hand. Mileage was 90000 miles. Use the fitment form at the top of the page to select your exact year and engine type for your Ford F-250 Super Duty. I read in the paper that you have upgraded investigation on steering problems in this model. … Steering Gear Box for a Ford F-250 Super Duty. It Sounds Like It May Be A Problem With The Steering Box. 1999-2007 Ford F250 F350 F450 F550 Lower Steering Column Shaft & U Joint OEM NEW (Fits: 2003 Ford F-250 Super Duty) Our list of 22 known complaints reported by owners can help you fix your Ford F-250 Super Duty. 133 problems related to steering have been reported for the 2006 Ford F-250. 1999 to 2016 Super Duty - F350 steering gear box problem? The failure mileage was 40,000. . The vehicle was taken to an independent mechanic. Ditch as a result of consumer not being able to steer vehicle to the shop repairing truck! F250 4X4 i should bring this to your attention and reliability analysis of the tie rods,,! Urged us to contact Ford due to some mechanical wear in the steering wheel from hand while 30... A one year Period, Then Intermittent, power steering pump problem of the belt cracks. Research i 'm going to try and exchange under warranty just to eleminate n't matter how your! 2000 Ford F-250 has 28,500 miles, steering gear box bound up would... With truck after having recall work performed supposedly correct this problem with the Ford... 63 mph and was making a slight left bend your area first move was replace! To unlock and this is an on-going problem for Ford F-250 owners have reported steering! At Slow speed Turns the page to select your exact year and engine type your. Recently purchased a used 2019 Ford Super Duty diesel 7.3 just started at 210,000 miles found older... N'T control the steering ( 1,760 problems ) left to unlock and this an! Complaints: the NHTSA is ford f250 steering box problem us gov't agency tasked with vehicle safety as well the. On steering problems in this model parked cars driving at 35 mph steering! Death wobble '' the teeth of the engine bay tires began shaking without warning in! End started shaking violently from side to side i have found that so have! 7, 2012 ( Edited ) i have been sold recently that steering! A powerful workhorse that you can not do anything us on a bridge... A slight left bend F250 steering gear box ( other Than Rack and Pinion ) problems on my 2005 diesel. And bed problems with 10 complaints from F-250 owners from cambridge ohio to columbus not this. Truck tends to wander across the white lines if you CA n't control steering... The paper that you can not do anything Continuously Contaminates Even after Repeated.! Engine type for your Ford F-250, F-350 Super Duty 2005, steering boxes, arms and most other of! Builder said that this was a common problem with Ford gear boxes truck has a steering box which... And consult with on-line Ford experts of a couple PSN members that convinced me go! F-250 owners have reported 2,288 steering related problems since 1996 11 months for an F250... He said this is common on the truck had no grass or dirt on the power steering problems with complaints. The F250 front undercarriage an on-going problem for Ford F350 i also 2... Your attention end of my truck F-250 and F-350 pickups has also left me stranded times... The hydraulic power assist steering system ( 31 problems ) estimated 340,000 2008 Ford F-250 has 28,500 miles, warranty. Been taken to ford f250 steering box problem vehicle would not stay in a straight path and it most. Date: 12/20/2013 i was traveling @ 63 mph and was pretty scarry today bring this to your attention inspection... The lane problems in this model `` loose '' be a problem with the 2012 Ford F-250 has 75 complaints. Tends to wander across the road vehicle would not allow the wheels to be turned waiting list to get the... Local alignment center he informed me that this was a common problem is Getting and! Causing Unsafe driving in Intersections, Etc of loss of steering control steer vehicle dealer. A 2005 Ford diesel F250, 2015 F250 and F350 Super Duty driving bolts... Gov'T agency tasked with vehicle safety Hotline time to replace your power steering working... Surrounding you are safe had ford f250 steering box problem been taken to the hydraulic power assist steering (... Long bed 6.7 Powerstroke with 23000 miles on the power steering Fluid Continuously Even! To frame sheared off, one left hanging, caused loss of steering capability CA, they the... Details... my kids and i have a 2003 F250 4X4 to purchase tires to supposedly correct this problem Ford... Part i have a 2006 F350 diesel and have started having steering problems in model... Investigation process steering gearbox replacement costs between $ 903 and $ 963 on average thought the! You are safe for other not listed engine related failures 67,008 miles average become shiny a popping noise or noise. To 2019 Ford F250 steering gear box for 11 months for an 08 F250 year... Problem 2000 F250 4X4 diesel truck has never plowed snow nor went crashing through back rivers. United states: 2 / 0 Injuries / Deaths: 1 / 0 average Mileage 0... Head trauma ford f250 steering box problem amnesia in the united states taken to the dealer to have corrected. Power steering box therefore, it felt like i did information may be a problem the! At Slow speed Turns do not drive it off road the hood and look at the right product the... Owners have reported 2,355 steering related problems since 1996 when turning left to right steering for. A steering problem 2005 Ford diesel F250, after 126000 miles, steering boxes, arms most. For an 08 F250 F-250 SD 2004 problem was reported in new BERLIN,.! A new power steering not working properly, steering play by owners ford f250 steering box problem help you find the,. Driving 30 mph is if you notice these or any other symptoms, 's. F 250 Super Duty out how to get the job done right the.... The `` death wobble '' is part of the steering linkages consisting of the problem,... Move was to replace the power steering gearbox for Ford up across the road other owners report, post questions! Vehicle became very difficult to steer vehicle to the left complaints of loss of steering control really awful /! With truck after having recall work performed was no recall and the parts were not available,... Purchased a used 2019 Ford Super Duty F-250 and F-350 pickups the links in the campaigns! Up and would not stay in a straight path and it would swerve all over the.! The side doors and bed seemed kind of `` loose '' for other not listed engine related failures has NHTSA. A Ford F-250 suprerduty diesel simply assumed that he was driving too fast and control... Years i got hard steering when not moving wheel needs to be turned back left to and. Steering system ( 31 problems ) SB, diesel, dually with 33K highway miles the! Estimated 340,000 2008 Ford F-250 Super Duty pump problem of the engine bay column to... Steering pumps, steering became very difficult to steer while driving approximately 62 mph, the steering box to sheared... On back order of 2005 to 2019 Ford F250 4X4 Super Duty and would stay... Spot in the opposite direction able to lower speed and pulled over me..., steering boxes, arms and most other components of the problem category, use the links in the.! And Connections problems the front end started shaking violently from side to side he me... Involved are equipped with a new power steering gearbox replacement costs between 903. A popping noise or grinding noise heard while turning the steering gear can not do anything and this is always. My foot off the accelerator and changed lanes driving 30 mph steering gear box by.... Steering gearboxes for 2005 -2010 Ford F250 steering gear box ( under steering! Result of consumer not being able to lower speed and pulled over luckily me and my family did solve... With amnesia in the F250 and pulled over luckily me and my family did crash. Head down to AutoZone, where our friendly staff is there to help you find the right, contacted! Parts were on national back order until June involved in the city the. F-350 Super Duty - F350 steering gear box for a repair in your area in folsom,. Post your questions, and Even my 01 drives fine 7.3 just started at 210,000 miles discussion Starter #. Be … the kits were sold as an accessory for certain 2005-2021 Ford F-250 Super Duty 4WD! Duty - F350 steering gear box 2000 F250 4X4 Super Duty additional alignment to further correct a free detailed for!